Page Contents:
In this article, you will find information about the fuses of the Ford F-Series F-150 (models 1997, 1998, 1999, 2000, 2001, 2002, and 2003), including diagrams of the fuse boxes, a list of fuses and relays, their designation, and the location of the fuse blocks within the vehicle.
Checking and Replacing Fuses in Ford F-150
If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components.
Caution!
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Always disconnect the battery before servicing high current fuses.
- Always replace the cover to the Power Distribution Box before reconnecting the battery or refilling fluid reservoirs.
Location of Fuse Boxes
Passenger compartment fuse panel:
The fuse panel is located below and to the left of the steering wheel by the brake pedal. Remove the panel cover to access the fuses. To remove a fuse use the fuse puller tool provided on the fuse panel cover.
See Also
Fuses and relay box diagram Ford F150 1997-2003Fuse Box Diagram Ford F-150 (1997-2003)Ford F-150 (1999-2003) Fuses and Fuse box diagram and LocationPower distribution box:
1997-1998:
Lift cover towards left of vehicle to access the power distribution box.
1999-2003:
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
Fuse Box Diagrams
1997
Passenger Compartment Fuses
List of fuses in the Passenger compartment fuse panel (1997)
| № | A | Description |
|---|---|---|
| 1 | 15A | Stop/turn lamps and turn indicators |
| 2 | 5A | Instrument cluster |
| 3 | 25A | Cigarette lighter |
| 4 | 5A | Power mirrors, autolamp, remote anti-theft / keyless entry, headlamp relay and parking lamp relay |
| 5 | 15A | Speed control, daytime running lamps, climate control blend door, backup lamps, A/C clutch coil |
| 6 | 5A | Brake-shift interlock, generic electronic module (GEM) / central timer module (CTM) and air suspension module |
| 7 | - | Not used |
| 8 | 5A | Radio, remote anti-theft / keyless entry, GEM module / CTM module |
| 9 | - | Not used |
| 10 | - | Not used |
| 11 | 30A | Wiper system |
| 12 | 5A | On-board diagnostic (OBD II) data link connector |
| 13 | 15A | Brake ON/OFF switch, rear anti-lock brake module and brake pressure switch |
| 14 | 15A | Interior lamps and accessory delay relay |
| 15 | 5A | GEM module / CTM module |
| 16 | 20A | High beam headlamps |
| 17 | - | Not used |
| 18 | 5A | Instrument illumination |
| 19 | 10A | Air bag diagnostic monitor, instrument cluster |
| 20 | 5A | GEM module / CTM module and powertrain control module (PCM) |
| 21 | 15A | Starter relay |
| 22 | 10A | Air bag diagnostic monitor and passenger air bag deactivate switch |
| 23 | 10A | 4WD clutch relay, electronic flasher, 4WD/2WD vacuum solenoids and trailer tow battery charge relay |
| 24 | 10A | l/P blower relay |
| 25 | 5A | 4WABS module and relay |
| 26 | 10A | Right low beam headlamp and DRL module |
| 27 | 5A | Foglamp relay |
| 28 | 10A | Left low beam headlamp |
| 29 | 5A | Autolamp, instrument cluster, transmission control indicator lamp and switch |
| 30 | 30A | Ignition coils and PCM relay |
| 31 | - | Not used |
| 1 | Interior lamps relay | |
| 2 | Battery saver relay | |
| 3 | Not used | |
| 4 | One touch down relay | |
| 5 | Accessory delay relay | |
Power Distribution Box
List of fuses in the Power distribution box (1997)
| № | A | Description |
|---|---|---|
| 1 | 20A | Trailer tow back-up and tail lamps |
| 2 | 10A | Air bag diagnostic monitor |
| 3 | 15A | Power locks |
| 4 | 15A | Air suspension |
| 5 | 20A | Horn |
| 6 | 15A | Audio system |
| 7 | 15A | Parking and tail lamps |
| 8 | 30A | Headlamps |
| 9 | 15A | Daytime running lamps and fog lamps |
| 10 | 25A | Auxiliary power point |
| 11 | - | Not used |
| 12 | - | Not used |
| 13 | - | Not used |
| 14 | 60A/20A | 4WABS / rear anti-lock brake |
| 15 | 50A | Air suspension compressor |
| 16 | 40A | Trailer tow battery charge and stop/turn lamps |
| 17 | 30A | 4WD transfer case shift motor and clutch |
| 18 | 30A | Driver power seat |
| 19 | 20A | Fuel pump |
| 20 | 50A | Instrument panel fuse panel ignition switch feed |
| 21 | 50A | Instrument panel fuse panel ignition switch feed |
| 22 | 50A | l/P fuse panel battery feed |
| 23 | 40A | l/P blower |
| 24 | 30A | PCM power |
| 25 | 30A | Power windows |
| 26 | - | Not used |
| 27 | - | Not used |
| 28 | 30A | Trailer tow electronic brake |
| 29 | - | Not used |
| 1 | Rear ABS diode | |
| 2 | PCM diode | |
| 1 | Windshield wipers HI/LO speed | |
| 2 | Windshield wipers run/park relay | |
| 3 | Washer pump relay | |
| 4 | Fuel pump relay | |
| 5 | Horn relay | |
| 6 | PCM power relay | |
Engine minifuse panel
The minifuse panel is located behind the power distribution box.
| № | A | Description |
|---|---|---|
| 1 | 5A | Powertrain control module (PCM) |
| 2 | 20A | Trailer tow stop/turn lamps |
| 3 | - | Not used |
| 4 | - | Not used |
| 5 | - | Not used |
| 6 | - | Not used |
Primary battery fuses (megafuses)
Primary battery fuses are located under the cover next to starter relay. Ford recommends that megafuses only be serviced by a qualified service technician.
| № | A | Description |
|---|---|---|
| 1 | 175A | Power network box megafuse |
| 2 | 175A | Alternator megafuse |
| 3 | 20A | Alternator field minifuse |
1998
Passenger Compartment Fuses
List of fuses in the Passenger compartment fuse panel (1998)
| № | A | Description |
|---|---|---|
| 1 | 15A | Flasher Relay |
| 2 | 5A | Instrument Cluster |
| 3 | 25A | Cigar Lighter |
| 4 | 5A | Park Lamp Relay, Headlamp Relay, Autolamp Module Remote Anti-Theft Personality (RAP) Module, Power Mirror Switch |
| 5 | 15A | Digital Transmission Range (DTR) Sensor (A/T), Backup Lamp Switch (M/T), Daytime Running Lights (DRL) Module, Speed Control Servo / Amplifier Assembly, Heater-A/C Control Assembly, Blend Door Actuator |
| 6 | 5A | Shift Lock Actuator, Generic Electronic Module (GEM), Rear Air Suspension (RAS) Module |
| 7 | - | Not Used |
| 8 | 5A | Radio, Main Light Switch, Remote Anti-Theft Personality (RAP) Module |
| 9 | - | Not Used |
| 10 | - | Not Used |
| 11 | 30A | Washer Pump Relay, Wiper Run/Park Relay, Wiper Hi/LO Relay, Windshield Wiper Motor |
| 12 | 5A | Data Link Connector (DLC) |
| 13 | 15A | Rear Anti-Lock Brake System (RABS) Module, Brake On/Off (BOO) Switch, Brake Pressure Switch |
| 14 | 15A | Battery Saver Relay, Interior Lamp Relay |
| 15 | 5A | Generic Electronic Module (GEM) |
| 16 | 20A | Instrument Cluster (W/O DRL), Daytime Running Lamps (DRL) Module, Hi-Beam Headlamps (Power supplied through Multi-Function Switch) |
| 17 | - | Not Used |
| 18 | 5A | Park Lamp Relay, Trailer Electronic Brake Controller, Main Light Switch, Trailer Tow Run Relay, Front Park/Turn Lamps, License Lamps, Stop/Park/Turn Lamps, Tail/Side Marker Lamps (Power supplied through Main Light Switch) |
| 19 | 10A | Instrument Cluster, Air Bag Diagnostic Monitor |
| 20 | 5A | Powertrain Control Module (PCM), Generic Electronic Module (GEM)/Central Timer Module (CTM) |
| 21 | 15A | Clutch Pedal Position (CPP) Switch (W/O RAP), Starter Interrupt Relay (W/RAP) |
| 22 | 10A | Air Bag Diagnostic Monitor, Passive De-Activation (PAD) Module |
| 23 | 10A | Trailer tow Battery Charge Relay, 4X4 Hub Solenoid, 4X2 Hub Solenoid, Flasher Relay, Shift on the Fly Relay |
| 24 | 10A | Blower Relay |
| 25 | 5A | 4 Wheel Anti-Lock Brake System (4WABS) Module, 4WABS Relay |
| 26 | 10A | Daytime Running Lamps (DRL) Module, Right Headlamp |
| 27 | 5A | Main Light Switch, Fog Lamp Relay |
| 28 | 10A | Left Headlamp |
| 29 | 5A | Autolamp Module, Instrument Cluster, Transmission Control Switch (TCS), Brake Warning Resistor/Diode Assembly (W/RABS) |
| 30 | 30A | Radio Noise Capacitor, Ignition Coil, PCM Power Diode |
| 31 | - | Not Used |
| Relay 1 | - | Interior Lamp Relay |
| Relay 2 | - | Battery Saver Relay |
| Not Used | - | Not Used |
| Relay 4 | - | One Touch Down Relay |
| Relay 5 | - | ACC Delay Relay |
Power Distribution Box
List of fuses in the Power distribution box (1998)
| № | A | Description |
|---|---|---|
| 1 | 20A | Trailer Tow Running Lamp Relay, Trailer Tow Backup Lamp Relay |
| 2 | 10A | Air Bag Diagnostic Monitor |
| 3 | 15A | All Unlock Relay, AH Lock Relay, Driver Unlock Relay, LH Power Door Lock Switch, RH Power Door Lock Switch |
| 4 | 15A | Rear Air Suspension (RAS) |
| 5 | 20A | Horn Relay |
| 6 | 15A | Radio, Premium Sound Amplifier, CD Changer |
| 7 | 15A | Main Light Switch, Park Lamp Relay |
| 8 | 30A | Main Light Switch, Headlamp Relay, Multi-Function Switch |
| 9 | 15 A | Daytime Running Lamps (DRL) Module, Fog Lamp Relay |
| 10 | 25A | Auxiliary Power Socket |
| 11 | - | Not Used |
| 12 | - | Not Used |
| 13 | - | Not Used |
| 14 | 60A/20A | 4 Wheel Anti-Lock Brake System (4WABS) Module / Ignition Switch (W/RABS Only) |
| 15 | 50A | Rear Air Suspension Compressor |
| 16 | 40A | Trailer Tow Battery Charge Relay, Engine Fuse Module (Fuse 2) |
| 17 | 30A | Shift on the Fly Relay, Transfer Case Shift Relay |
| 18 | 30A | Power Seat Control Switch |
| 19 | 20A | Fuel Pump Relay |
| 20 | 50A | Ignition Switch |
| 21 | 50A | Ignition Switch |
| 22 | 50A | Junction Box Fuse/Relay Panel Battery Feed |
| 23 | 40A | Blower Relay |
| 24 | 30A | PCM Power Relay, Engine Fuse Module (Fuse 1) |
| 25 | 30A | Junction Box Fuse/Relay Panel, ACC Delay Relay |
| 26 | - | Not Used |
| 27 | - | Not Used |
| 28 | 30A | Trailer Electronic Brake Controller |
| 29 | - | Not Used |
1999
Passenger Compartment Fuses
List of fuses in the Passenger compartment fuse panel (1999)
| № | A | Description |
|---|---|---|
| 1 | 15A | Audio |
| 2 | 5A | Powertrain Control Module (PCM), Cluster |
| 3 | 20A | Cigar Lighter, OBD-II Scan Tool Connector |
| 4 | 15A | Autolamp Module, Remote Entry Module, Mirrors |
| 5 | 15A | AC Clutch Relay, Speed Control Module, Reverse Lamp, Climate Mode Switch, Daytime Running Lamp Relay |
| 6 | 5A | Cluster, Brake Shift Interlock Solenoid, Rear Air Suspension Module, GEM Module |
| 7 | - | Not Used |
| 8 | 5A | Radio, Remote Entiy Module, GEM Module |
| 9 | - | Not Used |
| 10 | - | Not Used |
| 11 | 30A | Front Washer Pump Relay, Wiper Run/Park Relay, Wiper Hi/LO Relay, Windshield Wiper Motor |
| 12 | - | Not Used |
| 13 | 20A | Stop Lamp Switch (Lamps), Turn/Hazard Flasher, Speed Control Module |
| 14 | 15A | Battery Saver Relay, Interior Lamp Relay, Accessory Delay Relay (Power Windows) |
| 15 | 5A | Stop Lamp Switch, (Speed Control, Brake Shift Interlock, ABS, PCM Module Inputs), GEM Module, RABS Test Connector |
| 16 | 20A | Headlamps (Hi Beams), Cluster (Hi Beam Indicator) |
| 17 | - | Not Used |
| 18 | 5A | Instrument Illumination (Dimmer Switch Power) |
| 19 | - | Not Used |
| 20 | 5A | Audio, GEM Module, Powertrain Control Module (PCM), |
| 21 | 15A | Starter Relay, Clutch Switch, Fuse 20 |
| 22 | 10A | Air Bag Module, Passenger Airbag Deactivation Module |
| 23 | 10A | Trailer Tow Battery Charge Relay, Turn/Hazard Flasher, 4x4 Solenoids, 4x4 Relays |
| 24 | 10A | Climate Mode Switch (Blower Relay) |
| 25 | 5A | 4 Wheel Anti-Lock Brake System (4WABS) Module |
| 26 | 10A | Right Side Low Beam Headlamp |
| 27 | 5A | Foglamp Relay and Foglamp Indicator |
| 28 | 10A | Left Side Low Beam Headlamp |
| 29 | 5A | Autolamp Module, Transmission Overdrive Control Switch |
| 30 | 30A | Passive Anti Theft Transceiver, Cluster, Ignition Coils, Powertrain Control Module Relay |
| 31 | - | Not Used |
| Relay 1 | - | Interior Lamp |
| Relay 2 | - | Battery Saver |
| Relay 4 | - | One Touch Down Window |
| Relay 5 | - | ACC Delay |
Power Distribution Box
List of fuses in the Power distribution box (1999)
| № | A | Description |
|---|---|---|
| 1 | 25A | Power Point |
| 2 | 30A | Powertrain Control Module |
| 3 | 30A | Headlamps / Autolamps |
| 4 | 15A | Air Suspension |
| 5 | 20A | Trailer Tow Backup / Park Lamps |
| 6 | 15A | Parklamps / Autolamps |
| 7 | 20A | Horn |
| 8 | 15A | Power Door Locks |
| 9 | 15A | Daytime Running Lamps (DRL), Fog Lamps |
| 10 | 20A | Fuel Pump |
| 11 | 20A | Alternator Field |
| 12 | - | Not Used |
| 13 | - | Not Used |
| 14 | - | Not Used |
| 15 | - | Not Used |
| 16 | - | Not Used |
| 17 | - | Not Used |
| 18 | 15A | Powertrain Control Module, Fuel Injectors, Fuel Pump, Mass Air Flow Sensor |
| 19 | 10A | Trailer Tow Stop and Right Turn Lamp |
| 20 | 10A | Trailer Tow Stop and Left Turn Lamp |
| 21 | - | Not Used |
| 22 | - | Not Used |
| 23 | 15A | Powertrain Control Module, HE GO Sensor, Canister Vent |
| 24 | 15A | Powertrain C ontrol Module, Automatic Transmission, CMS Sensor |
| 101 | 30A | Trailer Tow Battery Charge |
| 102 | 50A/20A | Four Wheel Antilock Brake Module / Rear Wheel Antilock Brake Module |
| 103 | 50A | Junction Block Battery Feed |
| 104 | 30A | 4x4 Shift Motor & Clutch |
| 105 | 40A | Climate Control Front Blower |
| 106 | - | Not Used |
| 107 | - | Not Used |
| 108 | 30A | Trailer Tow Electric Brake |
| 109 | 50A | Air Suspension Compressor |
| 110 | 30A | Power Windows |
| 111 | 50A | Ignition Switch Battery Feed (Start and Run Circuits) |
| 112 | 30A | Drivers Power Seat |
| 113 | 50A | Ignition Switch Battery Feed (Run and Accessory Circuits) |
| 114 | - | Not Used |
| 115 | - | Not Used |
| 116 | - | Not Used |
| 117 | - | Not Used |
| 118 | - | Not Used |
| 201 | - | Trailer Tow Park Lamp Relay |
| 202 | - | Front Wiper Run/Park Relay |
| 203 | - | Trailer Tow Backup Lamp Relay |
| 204 | - | A/C Clutch Relay |
| 205 | - | Horn Relay |
| 206 | - | Fog Lamp Relay |
| 207 | - | Front Washer Pump Relay |
| 208 | - | Not Used |
| 209 | - | Front Wiper Hi/Lo Relay |
| 301 | - | Fuel Pump Relay |
| 302 | - | Trailer Tow Battery Charge Relay |
| 303 | - | Rear Air Suspension Relay |
| 304 | - | Powertrain Control Module Relay |
| 401 | - | Not Used |
| 501 | - | Powertrain Control Module Diode |
| 502 | - | A/C Clutch Diode |
| 503 | - | Not Used |
| 601 | - | Not Used |
| 602 | - | Not Used |
2000
Passenger Compartment Fuses
List of fuses in the Passenger compartment fuse panel (2000)
| № | A | Description |
|---|---|---|
| 1 | 15A | Audio |
| 2 | 5A | Powertrain Control Module (PCM), Cluster |
| 3 | 20A | Cigar Lighter, OBD-II Scan Tool Connector |
| 4 | 5A | Remote Entry Module, Mirrors |
| 5 | 15A | Speed Control Module, Reverse Lamp, Climate Mode Switch, Daytime Running Lamp Relay |
| 6 | 5A | Cluster, Brake Shift Interlock Solenoid, GEM Module |
| 7 | - | Not Used |
| 8 | 5A | Radio, Remote Entry Module, GEM Module |
| 9 | - | Not Used |
| 10 | - | Not Used |
| 11 | 30A | Front Washer Pump Relay, Wiper Run/Park Relay, Wiper Hi/LO Relay, Windshield Wiper Motor |
| 12 | - | Not Used |
| 13 | 20A | Stop Lamp Switch (Lamps), Turn/Hazard Flasher, Speed Control Module |
| 14 | 15A | Battery Saver Relay, Interior Lamp Relay, Accessory Delay Relay (Power Windows) |
| 15 | 5A | Stop Lamp Switch, (Speed Control, Brake Shift Interlock, ABS, PCM Module Inputs), GEM Module, RABS Test Connector |
| 16 | 20A | Headlamps (Hi Beams), Cluster (Hi Beam Indicator) |
| 17 | - | Not Used |
| 18 | 5A | Instrument Illumination (Dimmer Switch Power) |
| 19 | - | Not Used |
| 20 | 5A | Audio, GEM (or CTM) Module, Powertrain Control Module (PCM), |
| 21 | 15A | Starter Relay, Clutch Switch, Fuse 20 |
| 22 | 10A | Air Bag Module, Passenger Airbag Deactivation Module, Climate Mode Switch (Blower Relay) |
| 23 | 10A | Trailer Tow Battery Charge Relay, Turn/Hazard Flasher, 4x4 Solenoids, 4x4 Relays, Overhead Console, 4 Wheel Anti-Lock Brake System (4WABS) Module |
| 24 | - | Not Used |
| 25 | - | Not Used |
| 26 | 10A | Right Side Low Beam Headlamp |
| 27 | 5A | Foglamp Relay and Foglamp Indicator |
| 28 | 10A | Left Side Low Beam Headlamp |
| 29 | 5A | Autolamp Module, Transmission Overdrive Control Switch |
| 30 | 30A | Passive Anti Theft Transceiver, Cluster, Ignition Coils, Powertrain Control Module Relay |
| 31 | - | Not Used |
| Relay 1 | - | Interior Lamp Relay |
| Relay 2 | - | Battery Saver Relay |
| Relay 3 | - | Not Used |
| Relay 4 | - | One Touch Down Window Relay |
| Relay 5 | - | ACC Delay Relay |
Power Distribution Box
List of fuses in the Power distribution box (2000)
| № | A | Description |
|---|---|---|
| 1 | 20A | Power Point |
| 2 | 30A | Powertrain Control Module |
| 3 | 30A | Headlamps/Autolamps |
| 4 | - | Not Used |
| 5 | 20A | Trailer Tow Backup/Park Lamps |
| 6 | 15A | Parklamps/Autolamps, Passenger Fuse Panel Feed Fuse #18 |
| 7 | 20A | Horn |
| 8 | 15A | Power Door Locks |
| 9 | 15A | Daytime Running Lamps (DRL), Fog Lamps |
| 10 | 20A | Fuel Pump |
| 11 | 20A | Alternator Field |
| 12 | 20A | Rear Auxiliary Power Point |
| 13 | 15A | A/C Clutch |
| 14 | - | Not Used |
| 15 | - | Not Used |
| 16 | - | Not Used |
| 17 | - | Not Used |
| 18 | 15A | Powertrain Control Module, Fuel Injectors, Fuel Pump Relay, Idle Air Control, Mass Air Flow Sensor |
| 19 | 10A | Trailer Tow Stop and Right Turn Lamp |
| 20 | 10A | Trailer Tow Stop and Left Turn Lamp |
| 21 | - | Not Used |
| 22 | - | Not Used |
| 23 | 15A | HE GO Sensor, Canister Vent, Automatic Transmission, CMS Sensor |
| 24 | - | Not Used |
| 101 | 30A | Trailer Tow Battery Charge |
| 102 | 50A/20A | Four Wheel Antilock Brake Module / Rear Wheel Antilock Brake Module |
| 103 | 50A | Junction Block Battery Feed |
| 104 | 30A | 4x4 Shift Motor & Clutch |
| 105 | 40A | Climate Control Front Blower |
| 106 | 20A | Inter Cooler Pump (Lightning only) |
| 107 | - | Not Used |
| 108 | 30A | Trailer Tow Electric Brake |
| 109 | - | Not Used |
| 110 | 30A | Power Windows |
| 111 | 40A | Ignition Switch Battery Feed (Start and Run Circuits) |
| 112 | 30A | Drivers Power Seat, Adjustable Pedals |
| 113 | 40A | Ignition Switch Battery Feed (Run and Accessory Circuits) |
| 114 | - | Not Used |
| 115 | 20A | Power Door Locks (SuperCrew only) |
| 116 | - | Not Used |
| 117 | - | Not Used |
| 118 | - | Not Used |
| 201 | - | Trailer Tow Park Lamp Relay |
| 202 | - | Front Wiper Run/Park Relay |
| 203 | - | Trailer Tow Backup Lamp Relay |
| 204 | - | A/C Clutch Relay |
| 205 | - | Horn Relay |
| 206 | - | Fog Lamp Relay |
| 207 | - | Front Washer Pump Relay |
| 208 | - | Inter Cooler Pump Relay (Lightning only) |
| 209 | - | Front Wiper Hi/Lo Relay |
| 301 | - | Fuel Pump Relay |
| 302 | - | Trailer Tow Battery Charge Relay |
| 303 | - | Not Used |
| 304 | - | Powertrain Control Module Relay |
| 305 | - | Fuel Pump Hi/Lo Relay (Lightning only) |
| 306 | - | Inertia Switch Relay (Lightning only) |
| 401 | - | Not Used |
| 501 | - | Powertrain Control Module Diode |
| 502 | - | A/C Compressor Diode |
| 503 | - | Not Used |
| 601 | CB | Power Windows, Moonroof (SuperCrew only) |
| 602 | - | Not Used |
2001
Passenger Compartment Fuses
List of fuses in the Passenger compartment fuse panel (2001)
| № | A | Description |
|---|---|---|
| 1 | 15A | Audio |
| 2 | 5A | Powertrain Control Module (PCM), Cluster |
| 3 | 20A | Cigar Lighter, Data Link Connector |
| 4 | 5A | Exterior Rear View Mirror Switch, Mirror turn Signal Relays |
| 5 | 15A | Speed Control Module, Reverse Lamp, Climate Mode Switch, Daytime Running Lamp Relay, Digital Transmission Range (DTR) Sensor |
| 6 | 5A | Cluster, Brake Shift Interlock Solenoid, GEM Module |
| 7 | - | Not Used |
| 8 | 5A | Radio, Remote Entry Module, GEM Module, In-vehicle entertainment system (SuperCrew only) |
| 9 | - | Not Used |
| 10 | - | Not Used |
| 11 | 30A | Front Washer Pump Relay, Wiper Run/Park Relay, Wiper Hi/LO Relay, Windshield Wiper Motor |
| 12 | - | Not Used |
| 13 | 20A | Stop Lamp Switch (Lamps), Turn/Hazard Flasher |
| 14 | 15A | Battery Saver Relay, Interior Lamp Relay |
| 15 | 5A | Stop Lamp Switch, (Speed Control, Brake Shirt Interlock), GEM Module, RABS Module |
| 16 | 20A | Headlamps (Hi Beams), Cluster (Hi Beam Indicator) |
| 17 | - | Not Used |
| 18 | 5A | Instrument Illumination (Dimmer Switch Power) |
| 19 | - | Not Used |
| 20 | 5A | Audio, GEM Module, Powertrain Control Module (PCM), Transmission Range Sensor |
| 21 | 15A | Digital Transmission Range (DTR) Sensor, Clutch Switch, Starter Relay, I/P fuse 20 |
| 22 | 10A | Air Bag Module, Passenger Airbag Deactivation Module |
| 23 | 10A | Trailer Tow Battery Charge Relay, Turn/Hazard Flasher, 4x4 Solenoids, 4x4 Relays, Overhead Console, 4 Wheel Anti-Lock Brake System (4WABS) Module, EC Mirror, Heated Seats |
| 24 | 10A | Function Selector Switch Assembly |
| 25 | - | Not Used |
| 26 | 10A | Right Side Low Beam Headlamp |
| 27 | 5A | Foglamp Relay and Foglamp Indicator, Main Light Switch (upstream) |
| 28 | 10A | Left Side Low Beam Headlamp |
| 29 | 5A | Autolamp Module, Transmission Overdrive Control Switch, Central Security Module,Belt Minder |
| 30 | 30A | Passive Anti Theft Transceiver, Cluster, Ignition Coils, Powertrain Control Module Relay, Coil on Plugs, Radio Noise Capacitor, ECC Diode |
| 31 | - | Not Used |
| Relay 1 | - | Interior Lamp Relay |
| Relay 2 | - | Battery Saver Relay |
| Relay 3 | - | Not Used |
| Relay 4 | - | One Touch Down Window Relay |
| Relay 5 | - | ACC Delay Relay |
Power Distribution Box
List of fuses in the Power distribution box (2001)
| № | A | Description |
|---|---|---|
| 1 | 20A | Power Point |
| 2 | 30A | Powertrain Control Module |
| 3 | 30A | Main Light Switch, Headlamp Relay, Multifunction Switch |
| 4 | - | Not Used |
| 5 | 20A | Trailer Tow Backup/Park Lamps |
| 6 | 15A | Main Light Switch, Park Lamp Relay |
| 7 | 20A | Horn |
| 8 | 15A | Power Door Locks, CSM, Lock Relays |
| 9 | 15A | Daytime Running Lamps (DRL), Fog Lamps |
| 10 | 20A | Fuel Pump |
| 11 | 20A | Alternator Field |
| 12 | 20A | Rear Auxiliary Power Point |
| 13 | 15A | A/C Clutch |
| 14 | - | Not Used |
| 15 | 10A | Running Board Lamps (Supercrew only) |
| 16 | - | Not Used |
| 17 | - | Not Used |
| 18 | 15A | Powertrain Control Module, Fuel Injectors, Fuel Pump Relay, Mass Air Flow Sensor |
| 19 | 10A | Trailer/Camper Adapter (Right Stop and Right Turn Lamp) |
| 20 | 10A | Trailer/Camper Adapter (Left Stop and Left Turn Lamp) |
| 21 | - | Not Used |
| 22 | - | Not Used |
| 23 | 15A | HEGO Sensor, Automatic Transmission |
| 24 | - | Not Used |
| 101 | 30A | Trailer Tow Battery Charge |
| 102 | 50A/20A | Four Wheel Antilock Brake Module/Rear Wheel Antilock Brake Module, Ignition Switch |
| 103 | 50A | Central Junction Box |
| 104 | 30A | 4x4 Shift Motor & Clutch |
| 105 | 40A | Climate Control Front Blower |
| 106 | 20A | Inter Cooler Pump (Lightning only) |
| 107 | - | Not Used |
| 108 | 30A | Trailer Tow Electric Brake |
| 109 | - | Not Used |
| 110 | 30A | ACC Delay Relay |
| 111 | 40A | Ignition Switch Battery Feed (Start and Run Circuits) |
| 112 | 30A | Drivers Power Seat, Adjustable Pedal switch |
| 113 | 40A | Ignition Switch Battery Feed (Run and Accessory Circuits) |
| 114 | - | Not Used |
| 115 | 20A | Power Door Locks (SuperCrew only) |
| 116 | - | Not Used |
| 117 | - | Not Used |
| 118 | 30A | Heated Seats |
| 201 | - | Trailer Tow Park Lamp Relay |
| 202 | - | Front Wiper Run/Park Relay |
| 203 | - | Trailer Tow Backup Lamp Relay |
| 204 | - | A/C Clutch Relay |
| 205 | - | Horn Relay |
| 206 | - | Fog Lamp Relay |
| 207 | - | Front Washer Pump Relay |
| 208 | - | Inter Cooler Pump Relay (Lightning only) |
| 209 | - | Front Wiper Hi/Lo Relay |
| 301 | - | Fuel Pump Relay |
| 302 | - | Trailer Tow Battery Charge Relay |
| 303 | - | Not Used |
| 304 | - | Powertrain Control Module Relay |
| 305 | - | Fuel Pump Hi/Lo Relay (Lightning only) |
| 306 | - | Inertia Switch Relay (Lightning only) |
| 401 | - | Not Used |
| 501 | - | Powertrain Control Module Diode |
| 502 | - | A/C Compressor Diode |
| 503 | - | Not Used |
| 601 | CB | Power Windows, Moonroof (SuperCrew only) |
| 602 | - | Not Used |
2002
Passenger Compartment Fuses
List of fuses in the Passenger compartment fuse panel (2002)
| № | A | Description |
|---|---|---|
| 1 | 15A | Audio |
| 2 | 5A | Powertrain Control Module (PCM), Cluster |
| 3 | 20A | Cigar lighter, Data link connector |
| 4 | 5A | Power mirror switch, Mirror turn signal relays |
| 5 | 15A | Speed control module, Reverse lamp, Climate mode switch, Daytime Running Lamps (DRL) relay, Digital Transmission Range (DTR) sensor |
| 6 | 5A | Cluster, Brake shift interlock solenoid, GEM |
| 7 | - | Not used |
| 8 | 5A | Radio, Remote entry module, GEM, In-vehicle entertainment system (SuperCrew only) |
| 9 | - | Not used |
| 10 | - | Not used |
| 11 | 30A | Front washer pump relay, Wiper run/park relay, Wiper HI/LO relay, Windshield wiper motor |
| 12 | - | Not used |
| 13 | 20A | Stop lamp switch (Lamps), Turn/Hazard flasher |
| 14 | 15A | Battery saver relay, Interior lamp relay |
| 15 | 5A | Stop lamp switch (speed control, brake shift interlock), GEM, Rear Anti-lock Brake System (RABS) module |
| 16 | 20A | Headlamps (hi beams), Cluster (hi beam indicator) |
| 17 | - | Not used |
| 18 | 5A | Instrument illumination (dimmer switch power) |
| 19 | - | Not used |
| 20 | 5A | Audio, GEM, PCM, Transmission range sensor |
| 21 | 15A | DTR sensor, Clutch switch, Starter relay, I/P fuse 20 |
| 22 | 10A | Air bag module, Passenger air bag deactivation module |
| 23 | 10A | Trailer tow battery Charge relay, Turn/Hazard flasher, 4x4 solenoids, 4x4 relays, Overhead console, 4-Wheel Anti-lock Brake System (4WABS) module, EC mirror, Heated seats |
| 24 | 10A | Function selector switch assembly |
| 25 | - | Not used |
| 26 | 10A | Right-hand low beam headlamp |
| 27 | 5A | Foglamp relay and foglamp indicator, Main light switch (upstream) |
| 28 | 10A | Left-hand low beam headlamp |
| 29 | 5A | Autolamp module, Transmission overdrive control switch, Central security module, Beltminder |
| 30 | 30A | Passive Anti-theft transceiver, Cluster, Ignition coils, PCM relay, Coil on plugs, Radio noise capacitor, ECC diode |
| 31 | - | Not used |
| Relay 1 | - | Interior lamp relay |
| Relay 2 | - | Battery saver relay |
| Relay 3 | - | Not used |
| Relay 4 | - | One-touch down window relay |
| Relay 5 | - | Accessory delay relay |
Power Distribution Box
List of fuses in the Power distribution box (2002)
| № | A | Description |
|---|---|---|
| 1 | 20A | Power point |
| 2 | 30A | Powertrain Control Module (PCM) |
| 3 | 30A | Main light switch, Headlamp relay, Multifunction switch |
| 4 | - | Not used |
| 5 | 20A | Trailer tow back-up/park lamps |
| 6 | 15A | Main light switch, Park lamp relay |
| 7 | 20A | Horn |
| 8 | 15A | Power door locks, Central Security Module (CSM), Lock relays (not used on SuperCrew) |
| 9 | 15A | Daytime Running Lamps (DRL), Fog lamps |
| 10 | 20A | Fuel pump |
| 11 | 20A | Alternator field |
| 12 | 20A | Rear auxiliary power point (SuperCrew only) |
| 13 | 15A | A/C clutch |
| 14 | - | Not used |
| 15 | 10A | Running board lamps |
| 16 | - | Not used |
| 17 | - | Not used |
| 18 | 15A | PCM, Fuel injectors, Fuel pump relay, Mass air flow sensor |
| 19 | 10A | Trailer/Camper adapter (right stop/tum lamp) |
| 20 | 10A | Trailer/Camper adapter (left stop/tum lamp) |
| 21 | - | Not used |
| 22 | - | Not used |
| 23 | 15A | HE GO sensor, Automatic transmission |
| 24 | - | Not used |
| 101 | 30A | Trailer tow battery charge |
| 102 | 50A/20A | Four-wheel Anti-lock Brake System (4WABS) module/Rear-wheel Anti-lock Brake System (RABS) module, Ignition switch |
| 103 | 50A | Central junction box |
| 104 | 30A | 4x4 shift motor & clutch |
| 105 | 40A | Climate control front blower |
| 106 | 20A | Intercooler pump (supercharged engine only) |
| 107 | - | Not used |
| 108 | 30A | Trailer tow electric brake |
| 109 | - | Not used |
| 110 | 30A | Accessory delay relay (Not used on SuperCrew) |
| 111 | 40A | Ignition switch battery feed (start and run circuits) |
| 112 | 30A | Drivers power seat, Adjustable pedal switch |
| 113 | 40A | Ignition switch battery feed (run and accessory circuits) |
| 114 | - | Not used |
| 115 | 20A | Power door locks (SuperCrew only) |
| 116 | - | Not used |
| 117 | - | Not used |
| 118 | 30A | Heated seats |
| 201 | - | Trailer tow park lamp relay |
| 202 | - | Front wiper run/park relay |
| 203 | - | Trailer tow backup lamp relay |
| 204 | - | A/C clutch relay |
| 205 | - | Horn relay |
| 206 | - | Fog lamp relay |
| 207 | - | Front washer pump relay |
| 208 | - | Intercooler pump relay (supercharged engine only) |
| 209 | - | Front wiper HI/LO relay |
| 301 | - | Fuel pump relay |
| 302 | - | Trailer tow battery charge relay |
| 303 | - | Not used |
| 304 | - | PCM relay |
| 305 | - | Fuel pump HI/LO relay (supercharged engine only) |
| 306 | - | Inertia switch relay (supercharged engine only) |
| 401 | - | Not used |
| 501 | - | PCM diode |
| 502 | - | A/C compressor diode |
| 503 | - | Not used |
| 601 | CB | Power windows, Moonroof (SuperCrew only) |
| 602 | - | Not used |
2003
Passenger Compartment Fuses
List of fuses in the Passenger compartment fuse panel (2003)
| № | A | Description |
|---|---|---|
| 1 | 15A | Audio |
| 2 | 5A | Powertrain Control Module (PCM), Cluster |
| 3 | 20A | Cigar lighter, Data link connector |
| 4 | 5A | Power mirror switch, Mirror turn signal relays |
| 5 | 15A | Speed control module, Reverse lamp, Climate mode switch, Daytime Running Lamps (DRL) relay, Digital Transmission Range (DTR) sensor |
| 6 | 5A | Cluster, Brake shift interlock solenoid, GEM |
| 7 | - | Not used |
| 8 | 5A | Radio, Remote entry module, GEM, In-vehicle entertainment system (SuperCrew only) |
| 9 | - | Not used |
| 10 | - | Not used |
| 11 | 30A | Front washer pump relay, Wiper run/park relay, Wiper HI/LO relay, Windshield wiper motor |
| 12 | - | Not used |
| 13 | 20A | Stop lamp switch (Lamps), Turn/Hazard flasher |
| 14 | 15A | Battery saver relay, Interior lamp relay |
| 15 | 5A | Stop lamp switch (speed control, brake shift interlock), GEM, Rear Anti-lock Brake System (RABS) module |
| 16 | 20A | Headlamps (hi beams), Cluster (hi beam indicator) |
| 17 | - | Not used |
| 18 | 5A | Instrument illumination (dimmer switch power) |
| 19 | - | Not used |
| 20 | 5A | Audio, GEM, PCM, Transmission range sensor |
| 21 | 15A | DTR sensor, Clutch switch, Starter relay, I/P fuse 20 |
| 22 | 10A | Air bag module, Passenger air bag deactivation module |
| 23 | 10A | Trailer tow battery Charge relay, Turn/Hazard flasher, 4x4 solenoids, 4x4 relays, Overhead console, 4-Wheel Anti-lock Brake System (4WABS) module, EC mirror, Heated seats |
| 24 | 10A | Function selector switch assembly |
| 25 | 10A | Heated mirrors |
| 26 | 10A | Right-hand low beam headlamp |
| 27 | 5A | Foglamp relay and foglamp indicator, Main light switch (upstream) |
| 28 | 10A | Left-hand low beam headlamp |
| 29 | 5A | Autolamp module, Transmission overdrive control switch, Central security module, Beltminder |
| 30 | 30A | Passive Anti-theft transceiver, Cluster, Ignition coils, PCM relay, Coil on plugs, Radio noise capacitor, ECC diode |
| 31 | - | Not used |
| Relay 1 | - | Interior lamp relay |
| Relay 2 | - | Battery saver relay |
| Relay 3 | - | Not used |
| Relay 4 | - | One-touch down window relay |
| Relay 5 | - | Accessory delay relay |
Power Distribution Box
List of fuses in the Power distribution box (2003)
| № | A | Description |
|---|---|---|
| 1 | 20A | Power point |
| 2 | 30A | Powertrain Control Module (PCM) |
| 3 | 30A | Main light switch, Headlamp relay, Multifunction switch |
| 4 | 20A | Console power point (Harley Davidson only) |
| 5 | 20A | Trailer tow back-up/park lamps |
| 6 | 15A | Main light switch, Park lamp relay |
| 7 | 20A | Horn |
| 8 | 15A | Power door locks, Central Security Module (CSM), Lock relays (not used on SuperCrew) |
| 9 | 15A | Daytime Running Lamps (DRL), Fog lamps |
| 10 | 20A | Fuel pump |
| 11 | 20A | Alternator field |
| 12 | 20A | Rear auxiliary power point (SuperCrew only) |
| 13 | 15A | A/C clutch |
| 14 | - | Not used |
| 15 | 10A | Running board lamps |
| 16 | 15A | Bi-fuel injector module, fuel selector switch and alternative fuel injectors (Bi-fuel vehicles only) |
| 17 | - | Not used |
| 18 | 15A | PCM, Fuel injectors, Fuel pump relay, Mass air flow sensor |
| 19 | 10A | Trailer/Camper adapter (right stop/turn lamp) |
| 20 | 10A | Trailer/Camper adapter (left stop/turn lamp) |
| 21 | - | Not used |
| 22 | - | Not used |
| 23 | 15A | HE GO sensor, Automatic transmission |
| 24 | - | Not used |
| 101 | 30A | Trailer tow battery charge |
| 102 | 50A/20A | Four-wheel Anti-lock Brake System (4WABS) module/Rear-wheel Anti-lock Brake System (RABS) module, Ignition switch |
| 103 | 50A | Central junction box |
| 104 | 30A | 4x4 shift motor & clutch |
| 105 | 40A | Climate control front blower |
| 106 | 20A | Intercooler pump (supercharged engine only) |
| 107 | - | Not used |
| 108 | 30A | Trailer tow electric brake |
| 109 | - | Not used |
| 110 | 30A | Accessory delay relay (Not used on SuperCrew) |
| 111 | 40A | Ignition switch battery feed (start and run circuits) |
| 112 | 30A | Drivers power seat, Adjustable pedal switch |
| 113 | 40A | Ignition switch battery feed (run and accessory circuits) |
| 114 | - | Not used |
| 115 | 20A | Power door locks (SuperCrew only) |
| 116 | 40A | Heated backlight |
| 117 | - | Not used |
| 118 | 30A | Heated seats |
| 201 | - | Trailer tow park lamp relay |
| 202 | - | Front wiper run/park relay |
| 203 | - | Trailer tow backup lamp relay |
| 204 | - | A/C clutch relay |
| 205 | - | Horn relay |
| 206 | - | Fog lamp relay |
| 207 | - | Front washer pump relay |
| 208 | - | Intercooler pump relay (supercharged engine only) |
| 209 | - | Front wiper HI/LO relay |
| 301 | - | Fuel pump relay |
| 302 | - | Trailer tow battery charge relay |
| 303 | - | Heated backlight relay (SuperCrew only) |
| 304 | - | PCM relay |
| 305 | - | Fuel pump HI/LO relay (supercharged engine only) |
| 306 | - | Inertia switch relay (supercharged engine only) |
| 401 | - | Not used |
| 501 | - | PCM diode |
| 502 | - | A/C compressor diode |
| 503 | - | Not used |
| 601 | CB | Power windows, Moonroof (SuperCrew only) |
| 602 | - | Not used |
